PDF Parts Manual BT Prime Mover RS 40C Electric Straddle Truck - 15 MB
Find every component for your BT Prime Mover RS 40C Electric Straddle Truck in this detailed parts manual.
The manual contains clear, exploded-view diagrams and a complete list of part numbers.
This information is vital for accurate ordering and efficient repairs.
Ensure the longevity of your equipment by using the correct parts referenced in this official guide.
PDF Viewer
Viewer loads when you scroll here
SHARE THIS MANUAL
Download the PDF Manual
PDF viewer loading area
Text Preview from This Manual
The text below was extracted from the visible preview pages to help you confirm the manual contents before download.
--- Page 1 ---
PARTS MANUAL
Manual Number 9205
Manual Part Number 301040-001
RS-40C ELECTRIC STRADDLE TRUCK RS-40C
Read and observe all warnings on this
unit before operating it.
DO NOT operate this equipment unless all
factory installed guards and shields are
properly secured in place.
ISSUED MAY 1992
Return
--- Page 3 ---
FIG ITEM # FOR
# # PART # NAME ASSY. UNIT
1.1 1 14989-18 Screw, cap 4
1.1 2 -------------- Drive motor assembly (See Fig.# 1.2) 1
1.1 3 14994-06 Screw, cap 4
1.1 4 11016-04 Washer, flat 6
1.1 5 40011-01 Transmission assembly (See Fig.# 1.3 & 1.4) 1
1.1 6 14994-07 Screw, cap 2
1.1 7 20904-01 Bumper 1
1.1 8 40425-00 Shim, .005" As Req'd.
MAY 1992 1.2
--- Page 4 ---
FIGURE # 2.4 "EE" EV-100LX SCR ELECTRICAL SCHEMATIC SYMBOLS
MAY 1992 2.4
--- Page 5 ---
FIG ITEM # FOR
# # PART # NAME ASSY. UNIT
2.9 1 25332-01 Tie, wire As Req'd
2.9 2 41771-00 Harness, wiring(See Fig.# 2.6) 1
2.9 3 49611-00 Receptacle 1
2.9 4 49861-05 Relief, strain 1
2.9 5 52-07920-00 Cable As Req'd
21 FEET 89/180
21 FEET 89/192
23 FEET 95/198
23 FEET 95/210
25 FEET 107/226
26 FEET 111/240
28 FEET 119/258
2.9 6 11170-06 Nut 1
2.9 7 15677-08 Clamp 1
2.9 8 49610-00 Pin 5
2.9 9 11009-05 Lockwasher 2
2.9 10 11854-03 Screw, cap 2
2.9 11 40077-00 Bracket 1
2.9 12 49609-00 Plug 1
2.9 13 41255-00 Cable, reach (See Fig.# 2.10) 1
2.9 14 49608-00 Socket 5
2.9 15 41588-00 Sleeve, cable 2
2.9 16 49501-00 Spring 2
2.9 17 41602-00 Strain relief, clamp 2
2.9 18 41602-01 Strain relief, fitting 2
2.9 19 41596-00 Bracket 2
MAY 1992 2.14
--- Page 6 ---
FIG ITEM # FOR
# # PART # NAME ASSY. UNIT
2.14 1 41757-01 Panel assembly, 24 Volt contactor 1 24 Volt
2.14 1 41757-02 Panel assembly, 36 Volt contactor 1 36 Volt
2.14 2 27693-02 Contactor, 1A (See Fig.# 2.17) 1
2.14 3 50000-13 Washer, flat As Req'd
2.14 4 50001-11 Lockwasher As Req'd
2.14 5 50003-01 Screw, cap (M8x1.25MM 16M LG) As Req'd
2.14 6 301122-000 Bar, buss 1
2.14 6 NOT USED Bar, buss (NOT USED ON "EE" ONLY) 0 "EE"TYPE
2.14 7 27693-02 Contactor, 24 Volt lift pump 1 24 Volt
(See Fig.# 2.18)
2.14 * 300113-000 Suppression 1
2.14 7 27693-04 Contractor, 36 Volt lift pump 1 36 Volt
(See Fig.# 2.18)
2.14 * 300113-000 Suppression 1
2.14 8 300073-000 Contactor, auxiliary pump 1
(See Fig.# 2.19)
2.14 9 301121-000 Bar, buss 1
2.14 10 301125-000 Standoff 1
2.14 11 300110-000 Block, fuse 1
2.14 12 25275-06 Fuse, 15 AMP control 1
2.14 13 NSS Screw, machine (M3.5x0.6MM 8M LG) 1
2.14 14 301123-000 Bar, buss 1 "E" TYPE
2.14 15 301147-000 Harness, wiring 1
2.14 16 301120-000 Bar, buss 1
2.14 17 27692-00 Contactor, forward and rearward 1
(See Fig.# 2.16)
2.14 18 301126-000 Base 1
2.14 19 50003-02 Screw, machine (M8x1.25MM 20M LG) As Req'd.
2.14 20 50001-11 Lockwasher As Req'd.
2.14 21 50000-13 Washer, flat As Req'd.
2.14 22 25094-02 Fuse, 500 AMP power (FOR "E" ONLY) 1 "E" TYPE
2.14 22 25094-01 Fuse, 300 AMP power ("EE" DRIVE) 1 "EE"TYPE
2.14 23 25094-03 Fuse, 400 AMP power ("EE" HYDRAULIC) 1 "EE"TYPE
2.14 24 29408-00 Bar, buss 1 "EE"TYPE
2.14 25 202009 Suppression, forward/rearward 2
2.14 25 202004 Suppression, 1A contactor 1
* - NOT SHOWN BUT IS ON CONTACTOR PANEL ASSEMBLY (SEE ITEM # 25: EXAMPLE)
MAY 1992 2.24
--- Page 7 ---
EV-100LX POWER CONNECTOR ASSEMBLY (24 VOLT, 49855-24, RED)
FIG ITEM # FOR
# # PART # NAME ASSY. UNIT
2.19 1 49855-24 Connector assembly, RED SB-350 1
2.19 2 49854-05 Connector, RED housing 1
2.19 3 49852-03 Connector, tip 2
2.19 4 49853-04 Bushing 2
2.19 5 49856-121 Cable, 55.00" NEGATIVE 1
2.19 6 49856-120 Cable, 75.00", POSITIVE 1
EV-100LX POWER CONNECTOR ASSEMBLY (36 VOLT, 49855-22, GRAY)
FIG ITEM # FOR
# # PART # NAME ASSY. UNIT
2.19 1 49855-22 Connector assembly, GRAY SB-350 1
2.19 2 49854-02 Connector, GRAY housing 1
2.19 3 49852-03 Connector, tip 2
2.19 4 49853-04 Bushing 2
2.19 5 49856-121 Cable, 55.00" NEGATIVE 1
2.19 6 49856-120 Cable, 75.00", POSITIVE 1
MAY 1992 2.34
--- Page 8 ---
FIGURE # 2.25 "E" EV-100LX TT SCR ELECTRICAL SCHEMATIC SYMBOLS
MAY 1992 2.44
--- Page 9 ---
FIG ITEM # FOR
# # PART # NAME ASSY. UNIT
3.4 1 201546 Pin, roll 1
3.4 2 202138 Cam, switch 1
3.4 3 201643 Jam, nut 1
3.4 4 202139 Nut 2
3.4 5 201553 Lockwasher 2
3.4 6 202140 Bracket 1
3.4 7 202141 Cap 1
3.4 8 202142 Cap, adapter 1
3.4 9K NSS Ring, retainer 1
3.4 10 201578 Screw, machine 2
3.4 11 201556 Washer, flat 2
3.4 12 201639 Switch 1
3.4 13 202144 Plug 1
3.4 14K NSS O ring 1
3.4 15 201630 Spring 1
3.4 16 202091 Plunger 1
3.4 17 NA Body 1
3.4 18 NA Spool 1
3.4 19 201634 Bushing 1
3.4 20 202143 Spring 1
3.4 21 202096 Washer 1
3.4 22 202097 Washer 1
3.4 23K NSS O ring 2
3.4 24K NSS Seal, wiper 1
3.4 K 202104 Kit, seal 1
(CONTAINS ITEMS MARKED WITH "K")
MAY 1992 3.6
--- Page 10 ---
FIG ITEM # FOR
# # PART # NAME ASSY. UNIT
3.9 1 49640-07 Hose assembly, 89/126 1 89/126
3.9 1 49640-08 Hose assembly, 95/138 1 95/138
3.9 1 49840-09 Hose assembly, 107/162 1 107/162
3.9 1 49640-10 Hose assembly, 119/186 1 119/186
3.9 2 49632-01 Bulkhead, fitting 2
3.9 3 49604-01 O ring 2
3.9 4 49642-01 Hose 2
3.9 5 49654-01 Elbow, 45° 2
3.9 6 49604-01 O ring 1
3.9 7 12391-05 O ring 1
3.9 8 41331-00 Valve assembly, auxiliary control 1
(See Fig.# 3.4)
MAY 1992 3.16
--- Page 11 ---
FIG ITEM # FOR
# # PART # NAME ASSY. UNIT
3.14 1 41243-01 Coil, 24 volt 2
3.14 1 41243-00 Coil, 36 volt 2
3.14 2 41278-00 Valve, manifold 1
3.14 3 NA Block, valve 1
3.14 4 41187-00 Valve, solenoid 2
3.14 K 200073 Kit, seal (FOR ITEM #4) 1
MAY 1992 3.26
--- Page 12 ---
FIG ITEM # FOR
# # PART # NAME ASSY. UNIT
3.19 1 202093 Screw, machine 2
3.19 2 201624 Bracket 1
3.19 3 201556 Washer, flat 2
3.19 4 201578 Screw, machine 2
3.19 5 202094 Plug 1
3.19 6K NSS O ring 1
3.19 7K NSS Plunger 1
3.19 8 201618 Spring 1
3.19 9 201619 Plug 1
3.19 10K NSS O ring 1
3.19 11K NSS O ring 2
3.19 12 NA Body 2
3.19 13 NA Spool 1
3.19 14 202095 Valve, relief 1
3.19 15K NSS O ring 1
3.19 16K NSS Washer, backup 1
3.19 17K NSS O ring 1
3.19 18K NSS O ring 1
3.19 19 201616 Washer, deep 1
3.19 20 201560 Washer 1
3.19 21 201655 Spring 1
3.19 22 201533 Washer, shallow 1
3.19 23 201623 Screw, spool 1
3.19 24 201545 Nut 2
3.19 25 201639 Switch 1
3.19 26 201553 Lockwasher 2
3.19 K 201627 Kit, seal 1
(CONTAINS ITEMS MARKED WITH "K")
MAY 1992 3.36
--- Page 13 ---
FIG ITEM # FOR
# # PART # NAME ASSY. UNIT
3.24 1 49548-00 Screw 1
3.24 2 11897-03 Washer, seal 1
3.24 3 40728-01 Tube, 89/192 cylinder 1 89/192
3.24 3 40728-02 Tube, 95/210 cylinder 1 95/210
3.24 3 40728-03 Tube, 98/216 cylinder 1 98/216
3.24 3 40728-04 Tube, 102/225 cylinder 1 102/225
3.24 3 40728-05 Tube, 111/240 cylinder 1 111/240
3.24 3 40728-06 Tube, 119/258 cylinder 1 119/258
3.24 4 30555-00 Retainer 1
3.24 5 30556-00 Pin 1
3.24 6 30612-01 Spring 1
3.24 7 13857-01 Ball 1
3.24 8 28137-00 Piston 1
3.24 9K NSS Ring, wear 1
3.24 10 40730-01 Rod, 89/192 cylinder 1 89/192
3.24 10 40730-02 Rod, 95/210 cylinder 1 95/210
3.24 10 40730-03 Rod, 98/216 cylinder 1 98/216
3.24 10 40730-04 Rod, 102/225 cylinder 1 102/225
3.24 10 40730-05 Rod, 111/240 cylinder 1 111/240
3.24 10 40730-06 Rod, 119/258 cylinder 1 119/258
3.24 11K NSS O ring 1
3.24 12K NSS Ring, backup 1
3.24 13 28142-00 Bearing 1
3.24 14K NSS Ring, wear 1
3.24 15K NSS Seal 1
3.24 16K NSS Wiper 1
3.24 K 28200-00 Kit, seal 1
(CONTAINS ITEMS MARKED WITH "K")
MAY 1992 3.46
--- Page 14 ---
FIG ITEM # FOR
# # PART # NAME ASSY. UNIT
4.5 1 49919-03 Knob 1
4.5 2 14915-05 Plug, hole 1
4.5 3 40105-01 Crank, steering 1
4.5 4 11073-06 Pin, roll 1
4.5 5 40795-01 Torque generator (See Fig.# 3.8) 1
4.5 6 14994-11 Screw, cap 1
4.5 7 11854-03 Screw, cap 2
4.5 8 49796-00 Bearing, flange 1
4.5 9 11261-05 Nut 2
4.5 10 11047-21 Screw, cap 1
4.5 11 26466-01 Sprocket 1
4.5 12 11073-11 Pin, roll 1
4.5 13 40783-00 Sprocket 1
4.5 14 11271-11 Screw, cap 1
4.5 15 40782-00 Rod 1
4.5 16 49725-00 Bearing, pillow block 1
4.5 17 11830-03 Screw, cap 1
4.5 18 25125-01 Sprocket 1
4.5 19 11073-27 Pin, roll 1
4.5 20 20121-01 Chain 1
4.5 21 11057-03 Key 1
4.5 22 41079-00 Shim, .120" As Req'd.
4.5 22 41079-01 Shim, .060" As Req'd.
4.5 22 41079-02 Shim, .030" As Req'd.
4.5 23 11057-03 Key 1
4.5 24 21542-09 Chain 1
4.5 25 11170-08 Locknut 2
4.5 26 11016-04 Washer,flat 2
4.5 27 11857-01 Washer, 18 gauge 2
4.5 28 11857-02 Washer, 14 gauge 2
4.5 29 11936-17 Bearing, thrust 2
4.5 30 40780-00 Sprocket 2
4.5 31 11020-35 Bearing 2
4.5 32 40900-00 Sleeve, flanged 2
4.5 33 41138-00 Bracket, mounting 1
4.5 34 40781-00 Bolt, special 1
4.5 35 11806-06 Nut 1
4.5 36 40779-01 Screw, special 1
4.5 37 11873-16 Screw, shoulder 1
4.5 38 11695-07 Bearing, flange 1
MAY 1992 4.10
--- Page 15 ---
FIG ITEM # FOR
# # PART # NAME ASSY. UNIT
4.10 1 11073-33 Pin, roll 1
4.10 2 40245-00 Axle 1
4.10 3 41159-00 Bracket 1
4.10 4 40247-00 Pin 1
4.10 5 40249-00 Plate 2
4.10 6 11016-09 Washer 4
4.10 7 40248-01 Shim, .005" As Req'd.
4.10 7 40248-02 Shim, .010" As Req'd.
4.10 7 40248-03 Shim, .062" As Req'd.
4.10 7 40248-04 Shim, .031" As Req'd.
4.10 8 49972-05 Seal, oil 4
4.10 9 11205-21 Bearing 4
4.10 10 40222-00 Wheel 2
4.10 11 11160-09 Fitting, grease 2
4.10 * 202154 Adapter for grease gun 1
MAY 1992 4.20
--- Page 16 ---
FIG ITEM # FOR
# # PART # NAME ASSY. UNIT
5.3 1 11857-05 Shim, .050" As Req'd.
5.3 1 11857-12 Shim, .025" As Req'd.
5.3 2 21089-02 Bearing 2 89/126
5.3 3 14835-44 Chain, lift 89/126 2 95/138
5.3 3 14835-45 Chain, lift 95/138 2 107/162
5.3 3 14835-46 Chain, lift 107/162 2 119/186
5.3 3 14835-47 Chain, lift 119/186 2
5.3 4 30558-00 Anchor, chain 2
5.3 5 30554-00 Pin, chain 2
5.3 6 49837-00 Nut 2
5.3 7 11486-12 Nut, jum 2
5.3 8 -------------- Cylinder assembly (See Fig.# 5.4) 1
5.3 9 40518-01 Column, outer 89/126 1 89/126
5.3 9 40518-02 Column, outer 95/138 1 95/138
5.3 9 40518-03 Column, outer 107/162 1 107/162
5.3 9 40518-04 Column, outer 119/186 1 119/186
MAY 1992 5.6
--- Page 17 ---
FIG ITEM # FOR
# # PART # NAME ASSY. UNIT
5.8 1 40225-00 Guard, overhead 1
5.8 2 11170-12 Nut 4
5.8 3 14992-08 Screw, cap 4
5.8 4 14992-02 Screw, cap 1
5.8 5 -------------- Column, inner (See Fig.# 5.9) 1
5.8 6 -------------- Lift frame assembly (See Fig.# 5.13) 1
5.8 7 25008-01 Fork, 30" (See Fig.# 5.15) 2 30 inch
5.8 7 25008-02 Fork, 36" (See Fig.# 5.15) 2 36 inch
5.8 7 25008-03 Fork, 42" (See Fig.# 5.15) 2 42 inch
5.8 7 25008-04 Fork, 48" (See Fig.# 5.15) 2 48 inch
5.8 8 40472-00 Sideshifter assembly (See Fig.# 5.20) 1
5.8 9 30554-00 Pin with cotter pin 4
5.8 10 -------------- Column, intermediate (See Fig.# 5.11) 1
5.8 11 14992-17 Screw, cap 2
5.8 12 49925-01 Shim, .250" As Req'd. .250 inch
5.8 12 49925-02 Shim, .125" As Req'd. .125 inch
5.8 12 49925-03 Shim, .062" As Req'd. .062 inch
5.8 13 11016-06 Washer 2
5.8 14 11271-15 Screw, set 4
5.8 15 11271-14 Screw, set 4
5.8 16 40486-00 Screen (COLD STORAGE) 1 cold storage
5.8 17 52-05007-00 Edge, rubber (COLD STORAGE) As Req'd. cold storage
5.8 18 40228-03 Channel 1
5.8 19 40467-00 Channel, windshield 1
5.8 20 41084-00 Channel 2
5.8 20 41084-01 Channel, 95/210 2 95/210
5.8 21 -------------- Column, outer (See Fig.# 5.9) 1
5.8 22 NA Laminated safety sheet gless S.A.E. J-673 1
33 "x33¾"x.234" (Secure this part locally)
5.8 23 41082-00 Cap, plastic 2
MAY 1992 5.16
--- Page 18 ---
FIG ITEM # FOR
# # PART # NAME ASSY. UNIT
5.13 1 40771-00 Frame 1
5.13 2 14994-02 Screw, cap 2
5.13 3 40618-00 Bracket 1
5.13 4 11073-20 Pin, roll 2
5.13 5 40699-00 Pin 2
5.13 6 11857-05 Washer, shim As Req'd.
5.13 7 21089-02 Bearing 6
5.13 8 40637-00 Cylinder, tilt (See Fig.# 3.12) 2
5.13 9 14994-06 Screw, cap 12
5.13 10 40603-00 Clamp 4
5.13 11 40629-01 Pin 2
5.13 12 40600-00 Frame, fork 1
5.13 13 40382-01 Rod 1
5.13 14 11073-23 Pin, roll 1
5.13 15 40594-00 Rest, load 1
MAY 1992 5.26
--- Page 19 ---
FIG ITEM # FOR
# # PART # NAME ASSY. UNIT
7.5 1 49399-00 Control, EV-100LX SCR TX panel 1
(See Fig.# 2.12)
7.5 2 41757-01 Panel, 24 Volt contactor 1 24 VOLT
(See Fig.# 2.13 & 2.14)
7.5 2 41757-02 Panel, 36 Volt contactor 1 36 VOLT
(See Fig.# 2.13 & 2.14)
7.5 3 41799-00 Harness, curtis 1
7.5 4 301579-000 Wire assembly 1
7.5 5 49712-01 Lift interrupt control, 24 volt 1 24 VOLT
7.5 5 49712-02 Lift interrupt control, 36 volt 1 36 VOLT
7.5 6 301578-000 Gauge, lift interrupt 1
7.5 7 11016-01 Washer, flat 2
7.5 8 11009-04 Lockwasher 2
7.5 9 11045-04 Screw, cap 2
MAY 1992 7.6
--- Page 20 ---
MODEL RS-40C ELECTRIC STRADDLE TRUCK
NUMERICAL INDEX
PART # FIG. # ITEM # PART # FIG.# ITEM #
27693-02 2.14 7 300299-000 2.20 4
27693-04 2.14 7 300299-000 2.21 4
27899-00 2.11 11 300300-000 2.20 3
27899-00 3.16 1 300301-000 2.20 2
27900-00 2.11 11 300301-000 2.21 2
27900-00 3.16 1 300302-000 2.20 9
27901-00 2.11 17 300302-000 2.21 9
27901-00 1.2 31 300303-000 2.20 8
27902-00 1.2 31 300303-000 2.21 8
27902-00 2.11 17 300304-000 2.20 7
28137-00 3.24 8 300304-000 2.21 7
28142-00 3.24 13 300305-000 2.20 15
28142-00 3.23 11 300305-000 2.21 15
28159-04 5.11 21 300307-000 2.20 12
28159-06 5.11 11 300307-000 2.21 12
28200-00 3.24 K 300308-000 2.20 11
28200-00 3.23 K 300309-000 2.20 10
28286 2.24 8 300310-000 2.21 6
29030-01 2.23 1 300311-000 2.21 11
29030-02 2.23 1 300312-000 2.21 10
29304-00 2.6 11 300313-000 2.21 13
29304-00 4.4 56 300314-000 2.21 14
29329-00 2.13 6 300315-000 2.21 3
29408-00 2.14 24 300316-000 2.21 7
300073-000 2.14 8 300317-000 2.21 15
300074-001 2.18 1 300326-000 2.21 11
300074-002 2.18 3 300327-000 2.21 10
300074-003 2.18 7 300333-000 3.3 50
300074-004 2.18 10 300333-000 4.7 5
300084-000 2.12 10 300334-000 3.3 50
300085-000 2.12 32 300334-000 4.7 5
300086-000 2.12 21 300374-001 0.1 *
300110-000 2.14 11 300665-000 2.11 13
300110-000 2.24 12 300665-000 3.5 1
300113-000 2.14 * 300665-001 2.22 6
300113-000 2.14 * 300665-002 2.22 7
300143-000 3.6 21 300665-003 2.22 3
300184-000 3.6 K 300665-004 2.22 11
300246-000 3.17 14 300666-000 2.11 13
300247-000 3.17 7 300666-000 3.5 1
300249-000 3.17 10 300666-001 2.22 1
300249-000 3.17 2 300666-002 2.22 3
300250-000 3.17 K 300666-003 2.22 8
300292-000 2.20 5 300666-004 2.22 14
300292-000 2.21 5 300666-007 2.22 *
300293-000 2.20 6 300666-008 2.22 *
300294-000 2.21 1 300666-010 2.22 2
300294-000 2.20 1 300666-012 2.22 10
300295-000 2.20 11 300666-013 2.22 12
300296-000 2.20 10 300666-014 2.22 4
300297-000 2.20 14 300666-015 2.22 11
300298-000 2.20 13 300666-016 2.22 9
MAY 1992 99.7
--- Page 21 ---
PARTS ORDERING INSTRUCTIONS
HOW TO ORDER FIELD MODIFICATIONS
When you order, supply the part number, The regulations imposed by OSHA make it
quantity, model and serial numbers of your mandatory that alternation of industrial trucks
machine. Supplying this information will assure be done only as approved in advance and in
prompt, efficient handling of your order. The writing by the manufacturer. Their regulation
pictorial reference number is not needed and apply to counter-weighting, changes in masts
including it can only add confusion. when such changes affect capacity and any
other safety modifications. It is mandatory
Since your dealer carries many parts in stock that nameplate and instructions be changed
and maintains up-to-date prices on all parts, he accordingly (1910.178 (a)(4)).
will be able to process your order immediately.
If, for some reason, the part is not in stock, he BT PRIME-MOVER will approve such
will order it from the factory. In either event, he changes requested as we can properly
maintains a current file of service manuals, evaluate and rerate as to capacity. Normally
which give all available parts ordering or a change will be evaluated upon receipt of a
technical information. written request with full particulars including
truck and mast serial number, proposed
All prices are FOB factory in Muscatine, Iowa. changes, new heights of lift, etc.
Shipping charges are added to the price of the
part shipping from the factory. If the change is approved, authorization will be
sent as will new nameplates or other labeling
WHERE TO ORDER where appropriate. The new nameplates
should be installed over the earlier nameplate.
Always order parts from the dealer who sold
you your BT PRIME-MOVER. If it is necessary The modifier should send confirmation of the
for the dealer to order parts from the factory, he change to the factory along with pictures of
is able to get prompt service for you. Parts are the revised truck.
shipped in accordance with shipping instructions
given on the order.
INSTRUCTIONS FOR RETURNING PARTS
Under NO CIRCUMSTANCES will parts be
accepted at the factory for credit without prior
approval. THE BT PRIME-MOVER Co. cannot
accept responsibility for parts returned without
authorization.
If you have some parts which must be returned,
contact your dealer. If he believes parts should
be returned, he will arrange for authorization to
return the parts.
2 MAY 1992
--- Page 22 ---
FIGURE # 1.2 DRIVE MOTOR AND BRAKE ASSEMBLY
1.3 MAY 1992
--- Page 23 ---
FIGURE # 2.5 WIRING ASSEMBLY FOR COLD STORAGE
2.5 MAY 1992
--- Page 24 ---
FIGURE # 2.10 TILT WITH SIDESHIFTER CABLE ASSEMBLY
2.15 MAY 1992
--- Page 25 ---
FIGURE # 2.15 EV-100LX SCR FORWARD & REARWARD CONTACTOR ASSEMBLY (27692-00)
2.25 MAY 1992
--- Page 26 ---
FIGURE # 2.20 LIFT PUMP MOTOR ASSEMBLY, 24 VOLT (27900-00, 5BT1324B54) G.E.
LIFT PUMP MOTOR ASSEMBLY, 36 VOLT (27899-00, 5BT1326B234) G.E.
2.35 MAY 1992
--- Page 27 ---
FIGURE # 2.26 "EE" EV-100LX TT SCR ELECTRICAL SCHEMATIC
"EE" TT ELECTRICAL SCHEMATIC
2.45 MAY 1992
--- Page 28 ---
FIGURE # 3.3 AUXILIARY PUMP AND RESERVOIR ASSEMBLY
3.3 MAY 1992
--- Page 29 ---
FIGURE # 3.8 TORQUE GENERATOR ASSEMBLY (40795-01)
3.13 MAY 1992
--- Page 30 ---
FIGURE # 3.13 SIDESHIFTER CYLINDER WITH TILT ASSEMBLY
3.23 MAY 1992
--- Page 31 ---
FIGURE # 3.18 LIFT PUMP ASSEMBLY, 36 VOLT (41178-00)
3.33 MAY 1992
--- Page 32 ---
FIGURE # 3.23 THREE STAGE STAGING CYLINDER ASSEMBLY (41651-XX)
3.43 MAY 1992
--- Page 33 ---
FIGURE # 3.29 TWO STAGE MAST HYDRAULIC ASSEMBLY
SEE FIG.# 3.11, 3.13
FOR FURTHER BREAK DOWN.
3.53 MAY 1992
--- Page 34 ---
FIGURE # 4.4 HAND LIFT/LOWER AND SPEED CONTROL
4.7 MAY 1992
--- Page 36 ---
FIGURE # 4.9 SINGLE LOAD WHEEL ASSEMBLY
4.17 AUGUST 1993
--- Page 37 ---
FIGURE # 5.1 TWO STAGE MAST INSTALLATION
5.1 MAY 1992
--- Page 38 ---
FIGURE # 5.6 TWO STAGE SIDESHIFTER ASSEMBLY (41949-00 * 4" STROKE * 31" WIDE)
(41949-01 * 6" STROKE * 31" WIDE)
(41949-02 * 8" STROKE * 31" WIDE)
5.11 FEBRUARY 1993
--- Page 39 ---
FIGURE # 5.11 THREE STAGE INTERMEDIATE COLUMN ASSEMBLY
5.21 MAY 1992
--- Page 40 ---
FIGURE # 6.1 MANLIFT EV-100 LX SCR ELECTRICAL SCHEMATIC
6.1 DECEMBER 1991
--- Page 41 ---